• PLACE YOUR ADS HERE...
  • PLACE YOUR ADS HERE...

Average Rating  0 (0 Ratings & Reviews)


Wire Ropes & Slings in Doha Qatar


Care, Installation and Maintenance of WIRE ROPES

Information about wire rope unloading, storage, handling, installation, operation, lubrication, inspection, maintenance and possible causes for rope faults is given in this article to get best service from it.

Unloading

Whenever handling wire rope, take care not to drop reels or coils. This can damage wire rope and collapse the reel, making removal of the wire rope extremely difficult. Rope in a coil is unprotected and may be seriously damaged by dropping.

Storage

Wire ropes should be stored in a well ventilated, dry building or shed and shall not be in contact with the floor. If it is necessary to store them outside, cover them so that moisture cannot induce corrosion. The place should be free from dust, moisture and chemical fumes. To protect the wooden reels from the attack of termites, the floor should be cemented. Turning the reel occasionally, about half a turn, helps prevent migration of the rope lubricant. If ropes are to be stored for long time, it is advisable to examine them periodically and to apply dressing of lubricant to the top layer of rope on the drum.

Handling

Care must be taken when removing WIRE ROPES from reels or coils. When removing the rope from the reel or coil, the reel or coil MUST rotate as the rope unwinds. The Following illustrations demonstrate the right and wrong way of unreeling a rope.

Unreeling Wire Rope


  • MEP SUPPLIES ASSOCIATED TECHNICAL TRADING WLL SUPPLIERS IN DOHA QATAR
  •  LANDING ZONE INTERNATIONAL CO WLL SUPPLIERS IN DOHA QATAR
  • ELECTRICAL ACCESSORIES SUPPLIERS AL BALAGH TRADING & CONTRACTING CO WLL SUPPLIERS IN DOHA QATAR

For unreeling a reel, a spindle should be put through the reel and its ends jacked up to allow free rotation of the reel when the rope end is pulled. Rope in coil should be paid out from a turntable. Alternatively, where a coil is of short length, the outer end of the coil may be made free and the remainder rolled along the ground. Any attempt to unwind a rope from stationary reel or coil WILL result in a kinked rope. Looping the rope over the flange of the reel or pulling the rope off a coil while it is lying on the ground will create loops in the rope. If these loops are pulled tight, kinks will result.

Kink

kink is a permanent deformation or reshaping of rope. Kink leads to imbalance of lay length which will cause excessive wear. In severe cases, the rope will be so distorted that it will have only a small proportion of its strength. Thus a kink in wire rope results into premature wire rope failure. One of the most common causes for its formation is improper uncoiling and unrelling. If for any reason, a loop does form, ensure that it does not tighten to cause a kink which may lead to distortion of the rope.

When reeling wire rope from one reel to another or during installation on a drum it shall always bend in the same direction: i.e. pay out from the top of the reel to the top of the other reel, or from the bottom of the reel to the bottom of the other reel as illustrated below.

Rereeling Wire Rope

Reeling from top to bottom or from bottom to top can put a reverse bend into WIRE ROPES and must be avoided.


  •  MULTI TASK TRADING WLL SUPPLIERS IN DOHA QATAR
  • BUILDING MATERIALS AL JAMAL TRADING SUPPLIERS IN DOHA QATAR
  • BUILDING MATERIALS BELLAMAX INTERNATIONAL TRADING WLL SUPPLIERS IN DOHA QATAR

Operation

Equipment consisting of WIRE ROPES shall be operated a by well-trained operator only. A well-trained operator can prolong the service life of equipment and reduce costs by avoiding the potentially hazardous effects of overloading equipment, operating it at excessive speeds, taking up slack with a sudden jerk, and suddenly accelerating or decelerating equipment. The operator can look for causes and seek corrections whenever a danger exists. He or she can become a leader in carrying out safety measures – not merely for the good of the equipment and the production schedule, but, more importantly, for the safety of everyone concerned.

It is a common practice to leave a crane idle from one day to another or over a week end, with the rope at one position. This practice should be varied; otherwise the same part of the rope is constantly left on a bend leading to faster deterioration of that part of the rope.

Lubrication

Lubrication keeps rope flexible and enables wires to move in relation to each other. It also resists corrosion.

Although every rope is lubricated during manufacture, to lengthen its useful service life it must also be lubricated "in the field." A rope dressing of grease or oil shall be applied during installation. Subsequently the wire rope shall be cleaned and relubricated at regular intervals before the rope shows signs of dryness or corrosion. Wire rope may be cleaned by a wire brush, waste or by compressed air to remove all the foreign material and the old lubricant from the valleys between strands and wires. After cleaning the rope, it should never be cleaned using thin oils like kerosene or gasoline as it may penetrate into the core and do away with the internal lubrication. The use of relatively fluid dressings is sometimes preferred, which can easily penetrate between the outer wires of the rope, and displace any water, which may have entered. New lubricant may be applied by a brush or may be dripped on to the rope preferably at a point where the rope opens because of bending as shown below.

Lubrication

When ropes are to be stored for prolonged periods or used for special operating conditions, the heavier bituminastic type of dressing is preferable to low viscosity dressings, which tend to drain off the rope, thus exposing it to corrosion.

The lubricant used must be free from acids and alkalies and should have good adhesive strength (should be such that it cannot be easily wiped off or flung off by centrifugal force). It should be able to penetrate between the wires and strands. It should not decompose, have high film strength and resist oxidation.

Frequency of lubrication depends on operating conditions. The heavier the loads, the greater the number of bends, or the more adverse the conditions under which the rope operates, the more frequently lubrication will be required. For Source Info, Click here!


LIFTING SOLUTION

Nylon / Pp Ropes

STAINLESS STEEL WIRE ROPES & SLINGS

Webbing Slings

WIRE ROPES




Find below a list of the top Wire Ropes & Slings in Doha, Qatar:

  • ASSOCIATED TECHNICAL TRADING WLL
    Location: OFFICE 10, BLOCK 6, ARKAN BLDG, BARWA COMM AVE, INDL AREA ,
    Phone: 44769910;50811108 - MOBILE
    Timings:8.00AM-6.00PM
    Key Personnel:Safdar Grace, SALES DEPT
    SABEER MUHAMMED , TECHNICAL DEPT
    SHAHJAR ALI, PROCUREMENT DEPT
  • SOLARLINE TRADING & LOGISTICS WLL
    Location: OFFICE 3, ABDULLAH BIN THANI BLDG - 5, NR V I P R / A,
    Phone: 44622070
    Timings:8.00AM-6.00PM
    Key Personnel:SHALIN, TRADING
    HAFIS, LOGISTICS
  • LANDING ZONE INTERNATIONAL CO WLL
    Location: ST 45, GATE 11, INDL AREA,
    Phone: 44888756
    Timings:
    Key Personnel:DE QUAN ZHANG ( JOHAN ), M D
  • KINGFISHER TRADING & CONTRACTING CO
    Location: SHOP 18, BLDG 2, BARWA VILLAGE, AL WAKRAH,
    Phone: 40016386;44316996 - SHOWROOM;44317039;74492395 - TRANSPORTATION;55927317
    Timings:
    Key Personnel:THALHATH ABDUL AZEEZ, MKTG EXEC
  • TECHNICAL OILFIELD SUPPLIES CENTRE
    Location: ST 24, GATE 145, BLDG 295, SALWA IND AREA ,
    Phone: 44653426;44166607;44166608
    Timings:8.30AM-5.30PM
    Key Personnel:LIJU VARGHESE, OPS MNGR
    SUNDAR V, SALES ENGR
  • AL BALAGH TRADING & CONTRACTING CO WLL
    Location: AL HILAL AREA, D RING RD,
    Phone: 44667714;44667716;44665438
    Timings:7.00AM-5.00PM
    Key Personnel:VIJAY KUMAR BHATTACHARYA, Gen Mngr
    GETHESH KURIAN, SALES MNGR - TRADING DIV
    Henry A D' Souza, FIN MNGR
  • FK TOOLS
    Location: SHOP 25, BLDG 7, BARWA VILLAGE, AL WAKRAH ( SHOWROOM ); WAREHOUSE A4, NR LOGISTICS VILLAGE, ABA SALIL ( H O ),
    Phone: 44919599 - SHOWROOM;40363777 - H O
    Timings:7.00AM-5.00PM
    Key Personnel:VISHNU GOPAL, COUNTRY SALES MNGR
  • ALPHATECH SERVICES & TRADING WLL
    Location: OFFICE 14, BLDG 52, WHOLESALE MARKET, MESAIMIEER,
    Phone: 40060429;74061899 - MOBILE
    Timings:9.00AM-6.00PM
    Key Personnel:RAHUL SHETTY, DIRECTOR
    ROHIT SHETTY, FINANCE
    MS GLENDA, SALES CO-ORD
    PRAVEEN, PROJS
  • MULTI TASK TRADING WLL
    Location: SHOP 30, BLDG 3, BARWA VILLAGE, AL WAKRAH,
    Phone: 44328877
    Timings:8.00-1.00/4.00-8.30
    Key Personnel:Dr Binu , MNGR
  • PHOENIX PARTS & SERVICES WLL
    Location: OFFICE 31, 2ND FLR, BLOCK 6, ARKAN BLDG, BARWA COMM AVE, INDL AREA,
    Phone:
    Timings:8.30AM-5.30PM
    Key Personnel:VINOD PILLAI, B D M - SALES / SVC
    SABU KASSIM, FIN MNGR


Related Tags:
Wire Ropes & Slings in Doha Qatar | Associated Technical Trading Wll in Doha Qatar | Solarline Trading & Logistics Wll in Doha Qatar | Landing Zone International Co Wll in Doha Qatar | Kingfisher Trading & Contracting Co in Doha Qatar | Technical Oilfield Supplies Centre in Doha Qatar | Al Balagh Trading & Contracting Co Wll in Doha Qatar | Fk Tools in Doha Qatar | Alphatech Services & Trading Wll in Doha Qatar | Multi Task Trading Wll in Doha Qatar | Phoenix Parts & Services Wll in Doha Qatar |  Qatar Directory on Facebook |  Qatar Directory on Twitter |  Qatar Directory Online

WIRE ROPE & SLINGS

Wire Ropes & Slings in Doha Qatar


Find below a list of the top products suppliers of Wire Rope & Slings in Doha, Qatar:



Related Tags:
Wire Rope & Slings products in doha qatar | AJLAN Products in Doha Qatar | KISWIRE Products in Doha Qatar | LANDING ZONE INTL Products in Doha Qatar | SAAD AL KAABI Products in Doha Qatar | SAMSPLICE Products in Doha Qatar | SOLARLINE Products in Doha Qatar |  Qatar Directory on Facebook |  Qatar Directory on Twitter |  Qatar Directory Online



Author

Chantelle D'Mello

Chantelle D'mello is an avid writer with over four years of hard news experience as part of the award-winning Doha News team. She's previously worked at Al Jazeera and the Huffington Post, and hopes to bring her passion for writing to the Qatar Oil and Gas Directory.

Post Your Comments & Rating Here...

    

Please Note: Your Comments and rating are approved if it meets our company policy.


Reviews & Ratings

No Reviews Found
Categories
Recent Posts
Venetian Blinds In Doha Qatar
Forklift Hire Services In Doha Qatar
Polyurethane Insulation & Contg In Doha Qatar
Computer Accessories Suppliers In Doha Qatar
Industrial Refrigeration Contractors In Doha Qatar
Cold Rooms In Doha Qatar
Facade Cleaning Services In Doha Qatar
Tent Rental In Doha Qatar
Ventilating Fans In Doha Qatar
Document Management Services In Doha Qatar
Rubber Linings - Anti Corrosive In Doha Qatar
Electric Transmission & Distribution Equipment In Doha Qatar
Gas Companies In Doha Qatar
Serviced Offices In Doha Qatar
Corrosion Control Products In Doha Qatar
Oil Coolers In Doha Qatar
Mechanical Seals In Doha Qatar
Cable Glands & Accessories In Doha Qatar
Energy Meters In Doha Qatar
Engineering & Industrial Services In Doha Qatar
Labour Camp Leasing In Doha Qatar
Removal - Packing & Storage Services In Doha Qatar
Tank Mfrs & Suppliers In Doha Qatar
Hardware - Retail In Doha Qatar
Pvc Conduits & Fittings In Doha Qatar
Locks In Doha Qatar
Public Address Systems In Doha Qatar
Diesel Engines Suppliers In Doha Qatar
Office Machinery Suppliers In Doha Qatar
Corrosion Control Services In Doha Qatar
Steel Construction Products Suppliers In Doha Qatar
Drainage Products In Doha Qatar
Industrial Cleaning Contractors In Doha Qatar
Video Door Phones In Doha Qatar
Facilities Management And Maintenance In Doha Qatar
Industrial Cleaning Chemicals In Doha Qatar
Sandblasting & Grit Contractors In Doha Qatar
Dock Levellers In Doha Qatar
Hdpe Pipes & Fittings In Doha Qatar
Safety / Health / Environment Products & Services In Doha Qatar
Air Tools In Doha Qatar
Computer & Communication In Doha Qatar
Structural Steel Suppliers In Doha Qatar
Seals - Manufacturers In Doha Qatar
Property Management Companies In Doha Qatar
Garbage Disposal Contractors In Doha Qatar
Waterproofing Contractors & Services In Doha Qatar
Trucks / Trailers / Tankers - Rentals In Doha Qatar
Security Guard & Patrol Services - Comm & Ind In Doha Qatar
Food Testing In Doha Qatar